Chunky graphite formation in small section ductile iron castings
DOI:
https://doi.org/10.3989/revmetalm.1105Keywords:
Chunky graphite, Ductile iron, Small section casting, Cerium, Magnesium, Solidification curvesAbstract
Chunky graphite is a degenerated graphite form which can be found in the thermal centre of ductile iron heavy section castings. Previous studies made on cubic blocks (300 and 180 mm in side) manufactured using alloys with fully ferritic matrix structures show that low cooling rates, excessive post-inoculation and high silicon and/or cerium contents in the melts are the most important factors that promote this kind of defect. The enhancement of these critical factors led to obtain chunky graphite in sections lower than 50 mm. Different experimental conditions have been used in order to establish the main parameters that affect this graphite malformation. The use of cutting-edge techniques in the analysis of chemical compositions has revealed that no significant differences can be found when comparing chunky areas and well-formed spheroidal graphite areas. On the other hand, it has not been possible to establish any correlation between the oxygen contents and the scale of the defect. However, it is noteworthy that the oxygen content is related to the use of magnesium or cerium as nodulizer agent.
Downloads
References
[1] S. I. Karsay, AFS Trans. 78 (1970) 85-92.
[2] A. Javaid y C.R. Loper, AFS Trans. 103 (1995) 135-150.
[3] R. Kallböm, Mat. Sci. Eng. A 413-414 (2005) 346-351. http://dx.doi.org/10.1016/j.msea.2005.08.210
[4] I. Asenjo, P. Larrañaga, J. Sertucha, R. Suárez, J. M. Gómez, I. Ferrer y J. Lacaze, Int. J. Cast. Metal. Res. 20 (2007) 319-324. http://dx.doi.org/10.1179/136404608X286138
[5] Z. Ignaszak, Int. J. Cast. Metal. Res. 16 (2003) 93-97.
[6] A. Suárez-Sanabria y J. Fernández-Carrasquilla, Rev. Met. Madrid 42 (2006) 18-31.
[7] H. Itofuji y H. Uchikawa, AFS Trans. 98 (1990) 429-448.
[8] S. I. Karsay, Modern Casting 58 (1970) 85-192.
[9] M. Gagné, C. Labrecque y A. Javaid, AFS Trans. 115 (2007) trabajo 07-004.
[10] H. Nakae, S. Jung y H. C. Shin, J. Mater. Sci. Technol. 24 (2008) 289-295.
[11] J. Lacaze, S. Armendariz, P. Larrañaga, I. Asenjo, J. Sertucha y R. Suárez, Mat. Sci. Forum 636-637 (2010) 523-530. http://dx.doi.org/10.4028/www.scientific.net/MSF.636-637.523
[12] J. Sertucha, R. Suárez, I. Asenjo, P. Larrañaga, J. Lacaze, I. Ferrer y S. Armendariz, ISIJ Int. 49 (2009) 220-228. http://dx.doi.org/10.2355/isijinternational.49.220
[13] P. Larrañaga, I. Asenjo, J. Sertucha, R. Suárez, I. Ferrer y J. Lacaze, Int. J. Cast. Metal. Res. 22 (2009) 192-195. http://dx.doi.org/10.1179/136404609X367669
[14] P. Larrañaga, I. Asenjo, J. Sertucha, R. Suárez, I. Ferrer y J. Lacaze, Metall. Mater. Trans. A 40A (2009) 654-661.
[15] Z. Zhang, H. M. Flower y Y. Niu, Mater. Sci. Technol. 5 (1989) 657-664.
[16] K. Shoji, S. Masayuki, S. Haruyoshi y N. Kokichi, J. Japan Foundry Eng. Soc. 72 (2000) 311-316.
[17] H. Nakae, H. C. Shin, M. Hara y Y. Harada, J. Japan Foundry Eng. Soc. 75 (2003) 337-343.
[18] M. Homma y K. Hukuoka, Science Reports of the Research Institutes, Tohoku University, Senday, Japan, 1972, pp. 116-121.
[19] P. Larrañaga, J. M. Gutiérrez, A. Loizaga, J. Sertucha y R. Suárez, AFS Trans. 116 (2008) 547-561.
[20] M. Gagné y C. Labrecque, AFS Trans. 117 (2009) 561-571.
[21] R. Kallböm, K. Hamberg y L-E. Bjorkegren, Proc. 67thWorld Foundry Congress, Harrogate, England, 2006, trabajo 184.
[22] J. Lacaze, S. Méndez, J. Sertucha, P. Larrañaga, R. Suárez y I. Ferrer, Proc. The Carl Loper Cast Iron Symposium, Madison, EE.UU., 2009, pp. 59-68.
[23] X. Diao, Z. Ning, F. Cao, S. Ren y J. Sun, Key Eng. Mat. 457 (2011) 31-37. http://dx.doi.org/10.4028/www.scientific.net/KEM.457.31
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2011 Consejo Superior de Investigaciones Científicas (CSIC)
This work is licensed under a Creative Commons Attribution 4.0 International License.
© CSIC. Manuscripts published in both the printed and online versions of this Journal are the property of Consejo Superior de Investigaciones Científicas, and quoting this source is a requirement for any partial or full reproduction.All contents of this electronic edition, except where otherwise noted, are distributed under a “Creative Commons Attribution 4.0 International” (CC BY 4.0) License. You may read here the basic information and the legal text of the license. The indication of the CC BY 4.0 License must be expressly stated in this way when necessary.
Self-archiving in repositories, personal webpages or similar, of any version other than the published by the Editor, is not allowed.